Comparing Different Aluminium Leveller - Expert Analysis

There's only one Milenco Lightweight Aluminium Wheel Leveller model, so the real comparison isn't between different products — it's between the setups and use-cases the single design is built to cover.

Single-axle vs twin-axle

The leveller is designed to lift one wheel at a time, up to 1000kg per wheel. For a single-axle caravan or motorhome, one unit under the appropriate wheel is enough. For a twin-axle caravan, Milenco specifically notes you'll usually need two units — one per wheel — to level the whole outfit properly, so budget for a pair rather than a single unit if that's your setup.

Maximum travel vs usable lift

The screw bar offers up to 250mm of total travel, but the real-world usable lift is typically 120–180mm, depending on tyre and frame clearance and the state of the ground you're pitched on. It's worth checking your specific ground clearance before assuming you'll get the full 250mm in practice.

Ratchet vs traditional levelling blocks

The key practical difference this design offers over stacking traditional blocks or ramps is that you don't need to drive the vehicle back and forth to fine-tune the height — you ratchet the unit up or down once it's positioned, and there's no need to crawl underneath to check.

Choosing your setup

Work out whether your caravan is single or twin-axle first, since that determines whether you need one leveller or two, then check your typical pitch conditions against the 120–180mm usable lift range to confirm it will cover the unevenness you usually encounter.